United Launch Alliance has been attempting to launch a spy satellite for the National Reconnaissance Office, valued at more than $1 billion, for quite a while now. On Tuesday evening, just hours before the company's latest attempt to launch the large Delta IV Heavy booster, the mission was scrubbed again.
The weather at the launch site was far from optimal, but the mission was delayed due a technical problem with the launch pad. What is notable is that this is now the third issue that the company, ULA, has experienced with its ground systems equipment at Space Launch Complex-37 in Cape Canaveral, Florida for this flight.
The mission, dubbed NROL-44, was originally due to launch in June. When it was delayed until late August, military officials did not cite a reason for the schedule slip. However, on August 29, everything seemed nominal as the three-core rocket counted down to liftoff from its Florida-based launch pad. The countdown reached zero, the three main RS-68 engines ignited, and the launch conductor said, "Liftoff!"
But the rocket did not lift off. Instead, even as fires rose around the three cores, the rocket stayed put during a hotfire abort. This last-second scrub delayed the mission for a few weeks as engineers investigated the issue and eventually determined that a ground systems regulator caused the launch to abort. Essentially, three of these regulators at the pad deliver high-pressure helium into the main engines. The regulator for the center core engine failed.
On Twitter, the company's chief executive, Tory Bruno, wrote, "Found root cause of the pad side stuck regulator. Torn diaphragm, which can occur over time. Verifying the condition of the other 2 reg's. We will replace or rebuild as needed." Eventually the company would remove the regulators for all three engines, refurbish, and reinstall them. (Bruno did not respond to a request for comment for this story).
Nearly a month later, the company again prepared to launch the NROL-44 mission, even passing a launch readiness review. Then, a day before the September 26 launch date, the company delayed liftoff again. This time the culprit was a problem with the launch pad's swing arm retraction system, which pulls back fuel lines, and other connections from the rocket just before liftoff. The company took a few days to fix this problem, before setting a new launch date on September 29—Tuesday evening just before midnight.
Then, disaster struck again. Local storms caused a delay in pre-launch preparations. And when the mobile service tower that supports the rocket began to roll away a few hours before launch, it too had a problem. "When the MST roll began we discovered a hydraulic leak in the ground system required to move the tower which needs further evaluation," Read More – Source